Greenhouse side curtains

Greenhouse side curtains

We just finished installing our greenhouse side curtains on our geothermal heat sink project.  Typically a greenhouse will have sides that roll up to allow ventilation and excess heat to be removed.  Our Zimmerman High Tunnel kit is designed differently.

Our greenhouse side curtains are entirely different.  They attach along the sides near the bottom of the greenhouse.  When the sides are opened the curtain drops towards the ground from the hip board.

This picture below shows an open side curtain during the install process.  These is a side pocket on each end that prevents wind from blowing around the ends of the curtains.

greenhouse side curtain
this greenhouse side curtain is party open

How the side curtain operates

The operation of the side curtains to open and close is quite simple.  Through the use of a counter weight and winch one person and open and close the side curtain.  A length of cable runs from the winch on one end of the greenhouse, along the hip board, to a counter weight at the opposite of the greenhouse,

At the top of the top of the greenhouse side curtain is a hemmed pocket along the entire length.  Through that hem is length of pipe.  A small hole was made through the side curtain below the pipe approximately every 6 feet.  one end of a length of line is put through the hole and tied off around the pipe and curtain material.  the other end of the put through a pulley and then crimped onto the cable running between the winch and counter weight.

counter weight that lowers the greenhouse side curtain
When this counter weight is lowered the side curtain lowers
this winch operates the greenhouse side curtain
This winch lowers and raises the side curtain

As the cable is let out from the winch the curtain is lowered.  To raise the side curtain you simply operate the winch and bring in the cable.

Why a drop down greenhouse side curtain?

There are two reasons why I like the idea of a greenhouse side curtain like the one on the Zimmerman greenhouse kit.  By lowering the curtain towards the ground instead of from the ground up there are two advantages.

When the side curtain is open, the opening is at the top and not at the ground level as is typical for most greenhouses.  This allows the gardener to vent excess heat from closer to the peak of the greenhouse. This could be particularly advantageous for tall  plants that are grown vertically.

The second advantage is in helping to keep critters out of the greenhouse.  In the typical greenhouse when the side curtain rolls up from the bottom all nature of animals can easily get into the greenhouse.  Our side curtains are always secured at the bottom, making it more difficult for unwanted pests and animals to get inside.

3 thoughts on “Greenhouse side curtains”

  1. I been watching all your videos, really enjoying all of them. Just watched your video on egg shells. I’m not on face book so was wondering if you could help me out. I’m just now starting to experiment with the Mittleider method. My plants are grown in potting soil, do I need to take all the soil off before setting them out in the grow boxes with sawdust and sand mixture. I planted my broccoli and cabbage like I normally do with the soil attached and several are dying. I you can help I would appreciate it. Thanks Randy Puett

    1. Hi Randy. No, it isn’t necessary to remove the soil when transplanting. From your description of the cabbage and broccoli dying after transplanting it sounds like they’re experiencing transplant shock.

      A few suggestions, water the seedlings and the bed where they will be transplanted well before starting. Prune each plant while transplanting. This reduces the strain on the plant as it goes through the transplant. (It’s not too late to prune now. I’d remove the lowest leaves.) A little nitrogen, applied at 1/4 ounce per linear foot, will help get them through transplant shock.

      It seems counter intuitive, but handling the seedling by the leaves and not the stem during transplant is best. If you handle it by the stem and accidentally break it, the plant will die. If you rip or tear a leaf the plant will still survive.

      My next video is going to be on transplanting seedlings. It’s a little late to help you now, but perhaps it may help you in the future.

    2. I forgot to mention, I like to do my transplant in the afternoons. There is less direct sun to additionally stress the plants while they acclimate. Doing in this way allows them more recovery time before the dull sun of the following day hits them.

Leave a Reply

Your email address will not be published. Required fields are marked *